Product ID:R7 K 44 CATALYST REDUCER
MSDS Date:01/20/1987
FSC:8010
NIIN:00F006442
MSDS Number: BWHJV

SHERWIN-WILLIAMS CO

101 PROSPECT AVE N W
CLEVELAND, OH 44115-1042
US

Emergency Phone: 216-566-2917

Info Phone: 216-566-2902

Cage: 54636

SHERWIN-WILLIAMS CO THE

CLEVELAND, OH 44115-1042 US

Telephone: 800-251-2486/216-566-2242

Cage: 54636

PHOSPHORIC ACID

CAS: 7664-38-2

RTECS: TB6300000

Fraction By Weight: <5%

ACGIH TLV: 1 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 50%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM

2-BUTANONE (METHYL ETHYL KETONE) (MEK)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 45%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. MAY CAUSE
RESPIRATORY IRRITATION, NERVOUS SYSTEM DEPRESSION & DEATH.
OVEREXPOSURE TO THE INGREDIENTS MAY CAUSE ADVERSE EFFECTS TO LIVER,
URINARY & REPORDUCTIVE SYSTEMS. REPEATED /PROLONGED OVEREXPOSURE TO
SOLVENTS MAYCAUSE PERMANENT BRAIN/NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, NAUSEA,
CONFUSION, STAGGERING GAIT, UNCONSCIOUSNESS.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY W/SOAP & WATER. EYES:
FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINS. OBTAIN MEDICAL
ATTENTION IN ALL CASES.

Flash Point Method:PMCC
Flash Point:21F
Lower Limits:1.8
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WEAR SCBA & FULL PROTECTIVE EQUIPMENT. WATER
SPRAY MAY BE INEFFECTIVE. WATER MAY BE USED TO COOL CLOSED
CONTAINERS. FOG NOZZLES ARE PREFFERABLE.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATION TO HOT SURFACES REQUIRES
SPECIAL PRECAUTIONS.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.

Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED.
ISOLATE FROM IGNITION SOURCES. USE ONLY W/ADEQUATE VENTILATION.
KEEP CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:DON'T TAKE INTERALLY. KEEP OUT OF REACH OF CHILDREN.
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING THE
CONTENTS CAN BE HARMFUL/FATAL. AVOID BREATHING VAPOR/SPRAY MIST &
CONTACT W/SKIN & EYES.DON'T SMOKE. (SEE SUPP)

Respiratory Protection:WEAR RESPIRATORY DEVICE APPROVED BY NIOSH/MSHA
IF PERSONAL EXPOSURE CAN'T BE CONTROLLED < APPLICABLE LIMITS BY
VENTILATION.
Ventilation:LOCAL EXHAUST: PREFERABLE. GENERAL EXHAUST: ACCEPTABLE IF
EXPOSURE IS MAINTAINED < APPLICABLE EXPOSURE LIMITS.
Protective Gloves:RECOMMENDED
Eye Protection:REQUIRED
Other Protective Equipment:SAFETY GLASSES W/UNPERFORATED SIDESHIELDS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS AFTER USING.
Supplemental Safety and Health
OTHER PRECAUTIONS CONT'D: USE APPROVED BONDING/GROUNDING PROCEDURES.
TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE & APPROPRIATE
LABELING.

Boiling Pt:B.P. Text:174-212F
Vapor Density:>1
pH:2
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:98.6

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXTREME HEAT, SPARKS, OPEN FLAME,
ELECTRICAL EQUIPMENT & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CO2, CO, PHOSPHORIC ACID FUMES, OXIDES
OF PHOSPHORUS

Waste Disposal Methods:WASTE MUST BE TESTED FOR IGNITABILITY &
CORROSIVITY TO DETERMINE THE APPLICABLE EPA HAZARDOUS WASTE #'S.
INCINERATE IN APPROVED FACILITY IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T INCINERATE CLOSED CONTAINER.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.